Dell Axim X30 Screen Replacement

Introdução

The replacement of the screen is not difficult. Following the steps outlined in this guideline, one should be able to remove the necessary parts to the device to quickly access the screen. Please note that some of the pull tabs located inside the motherboard require some force when removing and reinserting. Take caution to not rip these pieces!

O que você precisa

Passo 1 Screen

Dell Axim X30 Screen Replacement, Screen: passo 1, imagem 1 %32

Dell Axim X30 Screen Replacement, Screen: passo 1, imagem 2 %32

Dell Axim X30 Screen Replacement, Screen: passo 1, imagem 3 %32

Remove the four rubber feet with your fingers.

Editar

Passo 2

Trigger battery release by inserting a nylon spudger into the battery release tab.
Slide tab and pull upwards on the battery to remove. Use the finger slots near the battery.

Editar

Passo 3

Remove the four 12.7mm screws under rubber feet with a JIS #0 screwdriver.

Editar

Passo 4

Remove back panel with a plastic opening tool. Follow the edge of the device around the entire perimeter.
The back panel should just pop off.

Editar

Passo 5

Dell Axim X30 Screen Replacement: passo 5, imagem 3 %32

Disconnect ribbon cables.
You may need to use a little force to disconnect them.
Disconnect red and white wired connector for speaker and motherboard battery.

Editar

Passo 6

Remove three 12.7mm JIS #0 screws.

Editar

Passo 7

Carefully remove motherboard.

Editar

Passo 8

Remove the two 9.6 mm screws by the speaker and green battery with a JIS #0 screwdriver.

Editar

Passo 9

Remove black plastic board.

Editar

Passo 10

Gently apply pressure on the right plastic frame by plastic clip marked on the picture.
Apply pressure to the bottom of the screen and press it towards you.
Remove screen from plastic case.